CZPT Design :GBT30/60 double stage pneumatic gasoline force take a look at pump for leakage testing
中部省 air driven fuel booster 水泵 are ratio devices that utilize minimal pressure compressed
air driving a greater diameter piston (spot x strain) which is linearly connected to a scaled-down
hydraulic piston/plunger. Using this ratio principal, a increased hydraulic force can be produced.
CZPT Pump design quantities reflect the pumps nominal pressure ratio, whilst the technical data
signifies specific ratios. The outlet stall stress is easy to established by modifying the air push pressure
by way of a easy air pressure regulator. By multiplying the stress ratio by the obtainable store
通过气压，可以计算出标称气体应力。
插图（P）ump 设计： GBT15/40 气体增压器 泵）
Air drive piston spot ( 160mm Ø)
CZPT plunger area ( twenty five毫米直径）
Actual ratio = forty:1
one. AIR Travel Section
The air drive section consists of a gentle excess weight piston total with seals operating inside of an
铝制枪管。气动活塞直径为160毫米。当向其提供压缩空气时
泵将空气泵入气缸，推动活塞向下进行压缩冲程。
(forces as out of the gasoline conclude).
Under the control of pilot pins (poppet valve) triggered at each stop of the stroke
two. GAS Driven Segment
CZPT气动增压器的气体部分由4个主要部件组成。
气筒、活塞、止回阀和主高压密封件。
气活塞与空气活塞直接相连，并位于气管内部。
它的上下运动产生气体流入和流出增压器。
止回阀。止回阀采用弹簧加载，在吸气冲程中工作。入口止回阀
opens to the greatest allowing fuel into the fuel barrel and on the compression stroke
the inlet verify valve closes the discharge verify valve opens forcing the pumped gas
进入该流程。主高压密封件位于气体活塞上，它们与……密封。
the gas barrel during operation . and the optimum pressures of the pump ,nevertheless the
CZPT PTFE seals are ideal for each the extensive majority of gases encountered .
可提供其他建筑材料以满足更严苛的服务要求。
CZPT系列增压器不适用于地下煤矿应用。
CZPT DO CZPT models of air pushed gas boosters t帽子不适合地下
煤矿应用。
CZPT Air pushed gasoline boosters cycle routinely as the outlet force increass the
阻力增大，循环频率降低，直至泵自动停止运转。
当输出压力相等时，这被称为失速状态。
当出口压力略微下降或气动压力升高时，水泵将重新启动。
增压器的性能会受到多种因素的影响，
例如排气消声器或先导阀冻结（这是由水分引起的）。
气路），进气管尺寸不足和过滤器脏污。操作增压器时
我们建议您持续使用每分钟 50-60 次循环的最大循环速率。
这样既可以延长保养周期，又能防止排气管结冰。
空气供应干燥器也有助于减少结冰。
CZPT气体增压器有 120毫米行程 从而降低给定流量下的循环速率
与其他大多数品牌相比，压力更低。这种较低的循环频率
最终导致冻结状况的减少。
为获得最佳整体性能，请勿减小指示的端口尺寸并咨询相关人员。
图表中未显示的流动条件下的 CZPT 测试。
Design variety for gas booster
务必记住，任何气动装置的性能都高度依赖于……
关于空气供应 条件。使用过小的空气压缩机或空气压缩机都可能导致供气受限。
航空公司。技术数据表中所示的流程图基于良好条件。
所以请不要“为了达到目标而设计”，要预留损耗和效率低下的空间。
The subsequent concern is wheather you want the booster to stall when an outlet strain is reached
If so ,a simple airline force regulator will suffice ,but don’t forget the flow drops off significantly as the
助推器达到失速状态。
如果您需要在特定压力下获得流量，那么您需要仔细且保守地解读流量图。
如果您需要泵在达到一定压力后停止运转，而不是停止，那么需要安装气动柱塞开关。
Crucial functions
Realiable ,Effortless to Sustain ,compact and sturdy
two. No heat,flame or spark threat
3. 无级变速循环速度和输出
four. Air driven Designs do not require electrical link ,effortless to use automatic controls
5. No restrict or adverse impact to contineous end/begin applications
six.Seals method designed for lengthy doing work life,No airline lubricated required
seven.Developed-in coupling program (Most models) and ideal for most gases boosting
Primary specialized info
Common complex data for double phase air pushed gas booster pump
| 设计 | 活塞杆直径 | 应力比 | Minimal inlet pressure PI(Bar) | 最大入口压力 PI (PO ) | Greatest Outlet strain PO(Bar) | Outlet strain system PO | 进气口尺寸 | Outlet porst measurement | Maximum Flow rate L/min= 7 Bar |
| GBT7/15 | 63/40 | 15:1 | 3.4 | 15 | 124 | 15PA+2PI | NPT3/8” | NPT3/8” | 215@PI=7 |
| GBT7/thirty | 63/28 | 32:1 | 三、四 | 十五 | 204 | 32PA+3PI | NPT3/8” | NPT1/4” | 118@PI=seven |
| GBT15/30 | 40/28 | 32:one | 七 | 40 | 204 | 32PA+2PI | NPT3/8” | NPT1/4” | 150@PI=10 |
| GBT15/forty-OL | 40/twenty five | 四十一 | 七 | 45 | 330 | 40PA+ 2PI | NPT3/8” | NPT1/4” | one hundred twenty five@PI=ten |
| GBT15/60 | 40/20 | 60:1 | 七 | 45 | 498 | 60PA+4PI | NPT3/8′ | NPT1/4” | ninety two@pi=ten |
| GBT30/sixty | 28/twenty | 60:1 | 30 | 45 | 498 | 60PA+2PI | NPT3/8” | NPT1/4” | 245@PI= 40 |
| GBT30/a hundred | 28/sixteen | 一百一 | 三十 | 70 | 830 | 100PA+ 3PI | NPT1/4” | NPT1/4” | 192 @pi=forty |
Remark 1) Maxium outlet pressure are at an air driven force of eight bar or 116 PSI ,for extended life making use of
of these kinds of pump ,we propose that air driven force must be not much more than eight Bar .
Typical software of these kinds of double stage air driven gas booster pump
制造工厂图片
